2. 职称英语
  3. TOMATO RIPENING Tomatoes give off minute quantities of ethy

TOMATO RIPENING Tomatoes give off minute quantities of ethy

游客2025-02-17  25
问题                  TOMATO RIPENING
    Tomatoes give off minute quantities of ethylene gas which is active in starting the natural ripening process. If left to nature, however, the tomatoes ripen in a random way. The trickled ethylene gas process of tomato ripening consists of exposing the tomatoes to a low concentration of ethylene gas under controlled temperature conditions in a special tomato-ripening room. This treatment initiates and controls the speed of the natural ripening and colouring process in the tomatoes.
    Controlled ripening and colouring enables the grower to market tomatoes of more uniform colour and quality than is possible with green or field-ripened produce. Timing of harvesting and marketing may, within limits, also be regulated by the use of controlled ripening and colouring in order to achieve maximum returns and make the best use of labour and equipment.
    Ripening Conditions
    All fruit must be mature green at harvest for controlled ripening to be successfully carried out. Relative humidity does not appear to be of great importance in the tomato-ripening process. Little moisture loss from the tomatoes occurs during the ripening process due to the relatively impermeable nature of the tomato skin. Ripening time will depend on the ripening temperature range; however, ripening temperatures above 24℃ will result in poor colour development with yellow or orange fruit rather than red. The heating and cooling capacity should be such that the tomatoes can be brought to the recommended ripening temperature within 24 hours.
    General Arrangement
    A typical arrangement for a tomato ripening room is shown in Figure 1 with the essential components of the system identified.
    Room Size and Construction
    For efficiency and convenience in operation, on-farm tomato ripening rooms are usually sized to accommodate the normal daily tomato pick during the peak harvest time. The room capacity is generally in the range of two to ten tonnes of tomatoes; however, larger rooms may sometimes be installed. Since the average ripening time is three or four days, the provision of multiple rooms on the one farm is generally desirable.
    Air Circulation and Ventilation System
    Fan-forced air circulation is required for adequate and uniform temperature control and ethylene gas distribution in the ripening room. An air circulation rate of two-room air volumes per minute is recommended for good results. This is equivalent to around 480 cubic metres of air per hour per tonne of tomatoes. At the recommended heating or cooling capacity of 0.6 to 1.2kw per tonne of tomatoes, this gives an air temperature differential of 3.5 to 7℃ across the heating or cooling system. These high air circulation rates are necessary to limit variations in temperature in different parts of the room to acceptable levels and to achieve an adequate rate of heating or cooling of the tomatoes.
    The ventilation system circulates the room air continuously, introducing a small proportion of fresh air and exhausting a similar amount of air at the same time. This prevents a build up of ethylene gas in the room and also removes carbon dioxide produced by the fruit during respiration. If this carbon dioxide were allowed to build up to too high a level in the room atmosphere, it would interfere with the ripening process.
    Temperature Control System
    The temperature of tomatoes in the ripening room has a great influence on the ripening process. In fact, the product heat load usually represents around 80% of the total heat load. The remainder is due to heat transmission through the external walls of the room and the fresh air exchange rate. In some cases, both heating and cooling are required to maintain the room temperature within the required range. The time required for ripening can be reduced to some extent by increasing the temperature. Reverse cycle air-conditioners are successfully used for both heating and cooling in tomato-ripening rooms where humidity control does not appear to be of great importance.
    Supply and Control Systems
    With the trickled ethylene gas system, a low concentration of ethylene gas is maintained in the ripening room atmosphere by a continuous small, controlled flow of gas of about 10 parts per million (ppm). Ethylene gas is supplied as bottled gas under high pressure and it is released into the ripening room through a pressure regulator and metering system.
    The outlet gas pressure is adjusted by means of the gas pressure regulator and the gas flow rate is then adjusted by the fine needle valve. A normally closed solenoid valve in the ethylene gas supply line ensures that gas is not discharged into the room unless the fans and ventilation system in the ripening room are operating. The solenoid valve is electrically interlocked with the operation of the ventilation system fans and is also controlled by an air flow switch. A gas control thermostat is used to measure when gas should be supplied to the room. The temperature-sensing element of this thermostat is pushed into a tomato so that it senses the pulp temperature of the tomatoes in different parts of the room.
    Provided that the ethylene gas supply and control systems are correctly arranged, the ethylene gas concentration in the room will not exceed the low level which is sufficient for ripening but is far below the explosion hazard level. Under these conditions, tomato-ripening rooms installed on farms and used only for ripening fruit produced by the owner have been approved by certain Electricity Commissions as not constituting a hazardous location.
    (Adapted from an article written by Brian Hesse for the ’Electrofarming Notebook’ for The South East Queensland Electricity Board, October 1989.) [br] *
选项
答案 variation
解析
转载请注明原文地址:https://tihaiku.com/zcyy/3961285.html
相关试题推荐
随机试题
最新回复(0)